Dream Maker Spas Dream Maker Ez Spa Hot Tub

Owners Manual Leisure Spa

C

Table Of Contents Introduction Important Safety Instructions

Page i 1-2

Choosing A Location

2

Power Requirements

3-4

Control System Diagram

5

Electrical Wiring Instructions

6

Start-Up Instructions

7-10

Troubleshooting

11-12

Spa Care and Maintenance

13-14

Water Quality and Maintenance

15-18

Spa Care and Maintenance Record

19

Warranty

20

13055 49th St. N. Clearwater, Florida 33762 (727) 573-9611

Introduction Your choice of a spa indicates that you are devoted to excellence. The manufacturer appreciates your patronage and take pride in the tradition of quality spas that our company represents. In order to get the most out of your spa, we strongly suggest that you take time to read through this manual before you hook up and operate your spa. This will acquaint you with the operating features, hook up procedures, maintenance, safety procedures, ensuring an enjoyable experience right from the start. Manufacturer has tried to anticipate all of your needs and desires; however, if you need any addition information, feel free to call your authorized dealer. WARNING!! This manual was written to ensure the proper use and installation of these spas. Any modifications to the procedures outlined in this manual may result in your warranty being void. Please take the time to read this manual to avoid any unnecessary problems with your brand new spa and equipment. THIS MANUAL AND ITS CONTENTS ARE SUBJECT TO CHANGE WITHOUT NOTICE. ALTHOUGH MANUFACTURER HAS PREPARED THIS MANUAL AS ACCURATE AND PRECISE AS POSSIBLE, WE WILL NOT BE LIABLE FOR LOSS, INJURY OR DAMAGES CAUSED BY IMPROPER INSTALLATION OR USE OR SPA (IMPROPER OR OTHERWISE).

This Manual Covers The Following Spas Z20, Z30, Z40, Z50

Date Purchased: Date Installed: Dealer Name: Dealer Address: Dealer Telephone: Spa Model and Serial Number: Part #7618 Manual Revised July 01, 2006 MANUFACTURE RESERVES THE RIGHT TO CHANGE SPECIFICATIONS WITHOUT NOTICE. i

IMPORTANT SAFETY INSTRUCTIONS When installing your spa and using this equipment, basic safety precautions should always be followed, to include the following: ! !

READ AND FOLLOW ALL INSTRUCTIONS! The following instructions are required by UL 1583 standard to be printed as a condition of their listing this product. They contain important safety information we strongly urge you to read and apply. DANGER - TO REDUCE THE RISK OF INJURY: Do not permit children to use spa unless they are closely supervised at all times.

WARNING

C

DURING PREGNANCY, SOAKING IN HOT TUB MAY CAUSE DAMAGE TO THE FETUS. LIMIT USE TIME TO 10 MINUTES AT A TIME

PREVENT DROWNING SPA HEAT SPEEDS UP EFFECTS OF ALCOHOL., DRUGS OR MEDICINE, AND CAN CAUSE UNCONSCIOUSNESS. IMMEDIATELY LEAVE SPA IF UNCOMFORTABLE OR SLEEPY.

PREVENT CHILD DROWNING WATER ATTRACTS CHILDREN. ALWAYS ATTACH A SPA COVER AFTER EACH USE. *ADDITIONAL COPIES MAY BE REQUESTED CALL THE TOLL-FREE NUMBER IN YOUR OWNERS MANUAL.

WARNING SIGN MUST BE POSTED The WARNING sign (RED) above is packed with your new Hydrospa Spa. This sign must be posted in a prominent place in close proximity to the spa installation site immediately upon completion of spa installation. !

! ! ! !

! ! ! ! ! ! ! !

WARNING SIGN - It is extremely important that this sign be permanently placed in clear view of any persons using the spa. Occasional spa users may not be aware of some of the dangers hot water poses to pregnant women, small children, and people under the influence of alcohol. If you did not receive a warning sign or your sign has become damaged, please contact your spa dealer or manufacturer. DANGER - A wire connector is provided on this unit to connect a minimum No. 8 AWG (8.4mm2) solid copper conductor between unit and any metal equipment, metal inclosures of electrical equipment, metal water pipe, or conduit, if that item is located within 5 feet (1.5m) of the unit. DANGER - RISK OF ACCIDENTAL DROWNING: Extreme Caution must be exercised at all times, to prevent unauthorized access by children. To avoid accidents, ensure that children cannot use spa unless th